Interpretation ID: nht76-3.32

DATE: 04/02/76

FROM: AUTHOR UNAVAILABLE; Frank A. Berndt; NHTSA

TO: Hackney & Sons Inc.

COPYEE: BUREAU OF MOTOR CARRIER SAFETY

TITLE: FMVSR INTERPRETATION

TEXT: This is in response to your letter of December 2, 1975, concerning the duties of a manufacturer of a beverage trailer that, when fully loaded, would overload a light-duty truck by which it might be towed.

The National Highway Traffic Safety Administration (NHTSA) does not directly regulate the use of motor vehicles. Instead, it regulates their manufacture, with a view towards their expected and intended uses. If a trailer manufacturer knows that his product is likely to be towed by a vehicle of insufficient load-carrying capacity, the NHTSA expects him to take reasonalbe steps, short of refraining from production, to minimize the likelihood of such misuse. Otherwise, the trailer would be considered to contain a defect relating to motor vehicle safety.

In the first hypothetical situation presented in your letter, there would be no violation of the Federal motor vehicle safety standards or regulations. In Situation 2, we are not prepared to state categorically whether or not the trailer manufacturer could be obliged to assume defect responsibility. Such responsibility might be minimized assuming that the written warning to which you refer clearly indicates (i) what load ratings are necessary as a minimum for the towing vehicle and (ii) that the trailer must not be towed by a vehicle without such load ratings. Nevertheless, the lines of responsibility between two such parties are not that clear-cut, especially where the trailer manufacturer knowingly delivers for introduction into interstate commerce a vehicle which immediately results in a serious overload situation.

In Situation 3, the trailer would probably contain a safety-related defect, because its advertising would promote its misuse in a way that would create a safety hazard. In Situation 4, the trailer would probably also be considered to contain a safety-related defect, because the total payload capacity could be calculated, and the warnings to limit the actual load to the limits of the towing vehicle could not reasonably be expected to be observed.

You have also asked more generally for a description of the circumstances under which trailers of this type might be considered to contain safety-related defects. The NHTSA cannot define in advance all such possible circumstances. Among them, however, would be those in which the owner's manual lacked the warning described above for Situation 2 and those in which the trailer's advertising promoted its misuse.

I have forwarded a copy of your letter to the Federal Highway Administration's Bureau of Motor Carrier Safety for examination of the possibility that the user of a mismatched combination of vehicles, if he is an interstate carrier, would be in violation of their regulations. There may also be State laws prohibiting local carriers from making such combinations.

Thank you for your concern for safety on the highways. We especially appreciate your realization that a manufacturer can have ethical duties that go beyond his legal duties.